?軸向柱塞泵的輸送功率為500W,泵送流量為18m3/h,最大流量可達3200m/h軸向柱塞泵采用的是四沖程油缸，工作中可以承受較大扭矩其軸向是對稱分布軸上有一條大凸輪軸向柱塞泵的軸端設有通孔，它與旋轉軸相連接。
這樣就可以使泵將液體吸入其腔室但這種結構不適合在回轉泵用中使用當流量不足時，這種泵可能由于軸和軸向不平衡而損壞_(1>nh;)=_nk這也就是為什么泵內不能正常工作原因分析主要原因是泵腔內壓不足，但也可能是油壓過高或油缸內有液壓油壓力過低都會造成嚴重后果是泵軸損壞或系統泄漏。
1.有可能出現泵軸損壞或系統泄漏 例如，當泵輸送相同體積的液體時，如流量為8m3/h,則不應使用泵軸此外，當壓力不足時，泵就會出現泵軸損壞或系統泄漏檢查泵是否在工作過程中突然停止，或者泵能否繼續運轉如果它不能繼續工作，則必須進行檢查。
如果出現問題，請在專業人士手中進行檢查或修理 2.泵軸向跳動或有裂紋 如果這種現象出現，那么需要檢查是不是有泄漏，是否導致泵內壓力不足，或是泵軸是否磨損或破裂如果發現了這些問題，那么需要更換油封如果是泵軸損壞而導致的故障，則需要更換新軸承或泵軸。
對于系統泄漏，可以嘗試通過調整泵壓力或卸下泵主軸來解決問題，一般都可以得到很好結果；如果泵軸泄漏可以檢查泵是否磨損或破裂，但它不是一個小問題，如果發現問題很嚴重，它會引起更大的問題 3.出現故障時應檢查活塞桿和齒輪嚙合是否正常、油路是否堵塞、泵腔內是否有液體以及密封圈是否損壞。
可以使用清潔的液壓油或汽油進行潤滑如果在工作中發現問題時，應及時處理一般來說，在使用中我們會遇到液壓泵流量不足和壓力低的情況這是因為液壓泵無法將泵內的液體輸送到出水口或出水管中此時，我們可以考慮將液壓泵重新安裝在泵體上。
如果泵體嚴重變形或磨損時，也可以更換新的液壓泵 4.有可能出現泵軸在工作時，由于軸的扭轉引起間隙過大，使泵的壓力過高從而造成了泵的無法正常工作 可以將泵軸的間隙調整為0.5-1mm左右，這樣做可以有效防止泵體內的壓力過高。
另外，當齒輪泵運轉過程中發生故障時，可根據故障情況先將齒輪泵中的齒輪部分取出，再將齒輪重新裝上后即可正常使用這種方法可以在短時間內解決泵內無法工作和泵不能工作問題具體可以按照上述原因進行分析處理 5.泵軸損壞后，可將油封拆下進行修理。
一般軸承處的損壞是由于機械加工精度和裝配偏差造成的如果您發現這些問題，應將其修復如已出現其他問題并無法修復請檢查故障原因 90-L-100-KA-5-NN-60-S-4-C6-E-03-GBA-38-38-24 90L100KA5NN60S4C6E03GBA383824 90L100-KA-5-NN-60-S-4-C7-E-02-GBA-38-38-28 90L100KA5NN60S4C7E02GBA383828 90-L-100-KA-5-NN-60-S-4-C7-E-02-GBA-38-38-28 90L100KA5NN60S4C7E02GBA383828 90L100-KA-5-NN-60-S-4-C7-E-03-GBA-35-35-20-F023 90L100KA5NN60S4C7E03GBA353520F023 90-L-100-KA-5-NN-60-S-4-C7-E-03-GBA-35-35-20-F023 90L100KA5NN60S4C7E03GBA353520F023 90L100-KA-5-NN-60-S-4-C7-E-03-GBA-42-42-24 90L100KA5NN60S4C7E03GBA424224 90-L-100-KA-5-NN-60-S-4-C7-E-03-GBA-42-42-24 90L100KA5NN60S4C7E03GBA424224 90L100-KA-5-NN-60-S-4-C7-E-05-FAC-38-38-28 90L100KA5NN60S4C7E05FAC383828 90-L-100-KA-5-NN-60-S-4-C7-E-05-FAC-38-38-28 90L100KA5NN60S4C7E05FAC383828 90L100-KA-5-NN-60-S-4-C7-E-05-FAC-38-38-28-F023 90L100KA5NN60S4C7E05FAC383828F023 90-L-100-KA-5-NN-60-S-4-C7-E-05-FAC-38-38-28-F023 90L100KA5NN60S4C7E05FAC383828F023 90-L-100-KA-5-NN-60-S-4-C7-F-02-FAC-38-38-28-F023 90L100KA5NN60S4C7F02FAC383828F023 90-L-100-KA-5-NN-60-S-4-C7-F-03-FAC-32-32-24 90L100KA5NN60S4C7F03FAC323224 90-L-100-KA-5-NN-60-S-4-F1-F-03-FAC-32-32-24 90L100KA5NN60S4F1F03FAC323224 90L100-KA-5-NN-60-S-4-T2-E-05-GBA-29-29-24 90L100KA5NN60S4T2E05GBA292924 90-L-100-KA-5-NN-60-S-4-T2-E-05-GBA-29-29-24 90L100KA5NN60S4T2E05GBA292924 90L100-KA-5-NN-80-D-3-C7-E-03-GBA-42-42-24-P000 90L100KA5NN80D3C7E03GBA424224P000 90-L-100-KA-5-NN-80-D-3-C7-E-03-GBA-42-42-24-P000 90L100KA5NN80D3C7E03GBA424224P000 90L100-KA-5-NN-80-L-3-C7-E-00-GBA-35-35-24 90L100KA5NN80L3C7E00GBA353524 90-L-100-KA-5-NN-80-L-3-C7-E-00-GBA-35-35-24 90L100KA5NN80L3C7E00GBA353524 90L100-KA-5-NN-80-L-3-C7-F-03-GBA-42-42-28 90L100KA5NN80L3C7F03GBA424228 90-L-100-KA-5-NN-80-L-3-C7-F-03-GBA-42-42-28 90L100KA5NN80L3C7F03GBA424228 90L100-KA-5-NN-80-L-4-C7-E-03-GBA-29-29-24 90L100KA5NN80L4C7E03GBA292924 90-L-100-KA-5-NN-80-L-4-C7-E-03-GBA-29-29-24 90L100KA5NN80L4C7E03GBA292924 90L100-KA-5-NN-80-P-3-C7-E-03-GBA-26-26-24 90L100KA5NN80P3C7E03GBA262624 90-L-100-KA-5-NN-80-P-3-C7-E-03-GBA-26-26-24 90L100KA5NN80P3C7E03GBA262624 90L100-KA-5-NN-80-P-3-C7-E-03-GBA-38-38-24 90L100KA5NN80P3C7E03GBA383824 90-L-100-KA-5-NN-80-P-3-C7-E-03-GBA-38-38-24 90L100KA5NN80P3C7E03GBA383824 90L100-KA-5-NN-80-P-3-C7-F-03-GBA-32-32-24 90L100KA5NN80P3C7F03GBA323224 90-L-100-KA-5-NN-80-P-3-C7-F-03-GBA-32-32-24 90L100KA5NN80P3C7F03GBA323224 90L100-KA-5-NN-80-P-3-S1-E-03-GBA-42-42-24 90L100KA5NN80P3S1E03GBA424224 90-L-100-KA-5-NN-80-P-3-S1-E-03-GBA-42-42-24 90L100KA5NN80P3S1E03GBA424224 90L100-KA-5-NN-80-P-4-S1-F-03-GBA-38-38-28 90L100KA5NN80P4S1F03GBA383828 90-L-100-KA-5-NN-80-P-4-S1-F-03-GBA-38-38-28 90L100KA5NN80P4S1F03GBA383828 90L100-KA-5-NN-80-P-4-T2-E-03-GBA-30-30-24 90L100KA5NN80P4T2E03GBA303024 90-L-100-KA-5-NN-80-P-4-T2-E-03-GBA-30-30-24 90L100KA5NN80P4T2E03GBA303024 90L100-KA-5-NN-80-R-3-C7-F-03-GBA-26-26-24 90L100KA5NN80R3C7F03GBA262624 90-L-100-KA-5-NN-80-R-3-C7-F-03-GBA-26-26-24 90L100KA5NN80R3C7F03GBA262624 90L100-KA-5-NN-80-R-3-F1-E-03-GBA-32-32-20 90L100KA5NN80R3F1E03GBA323220 90-L-100-KA-5-NN-80-R-3-F1-E-03-GBA-32-32-20 90L100KA5NN80R3F1E03GBA323220 90L100-KA-5-NN-80-R-3-F1-E-03-GBA-32-32-20-G005 90L100KA5NN80R3F1E03GBA323220G005 90-L-100-KA-5-NN-80-R-3-F1-E-03-GBA-32-32-20-G005 90L100KA5NN80R3F1E03GBA323220G005 90L100-KA-5-NN-80-R-3-S1-E-03-GBA-35-35-24 90L100KA5NN80R3S1E03GBA353524 90-L-100-KA-5-NN-80-R-3-S1-E-03-GBA-35-35-24 90L100KA5NN80R3S1E03GBA353524 90L100-KA-5-NN-80-R-4-C7-E-03-GBA-29-29-26-F023 90L100KA5NN80R4C7E03GBA292926F023 90-L-100-KA-5-NN-80-R-4-C7-E-03-GBA-29-29-26-F023 90L100KA5NN80R4C7E03GBA292926F023 90L100-KA-5-NN-80-R-4-C7-E-03-GBA-35-35-24 90L100KA5NN80R4C7E03GBA353524 90-L-100-KA-5-NN-80-R-4-C7-E-03-GBA-35-35-24 90L100KA5NN80R4C7E03GBA353524 90L100-KA-5-NN-80-R-4-C7-F-03-GBA-26-26-26 90L100KA5NN80R4C7F03GBA262626 90-L-100-KA-5-NN-80-R-4-C7-F-03-GBA-26-26-26 90L100KA5NN80R4C7F03GBA262626 90L100-KA-5-NN-80-R-4-C7-F-03-GBA-26-26-30-F068 90L100KA5NN80R4C7F03GBA262630F068 90-L-100-KA-5-NN-80-R-4-C7-F-03-GBA-26-26-30-F068 90L100KA5NN80R4C7F03GBA262630F068 90L100-KA-5-NN-80-R-4-C7-F-03-GBA-26-32-26 90L100KA5NN80R4C7F03GBA263226 90-L-100-KA-5-NN-80-R-4-C7-F-03-GBA-26-32-26 90L100KA5NN80R4C7F03GBA263226 90L100-KA-5-NN-80-R-4-C7-F-03-GBA-29-29-30-F068 90L100KA5NN80R4C7F03GBA292930F068 90-L-100-KA-5-NN-80-R-4-C7-F-03-GBA-29-29-30-F068 90L100KA5NN80R4C7F03GBA292930F068 90L100-KA-5-NN-80-R-4-C7-F-03-GBA-32-32-30 90L100KA5NN80R4C7F03GBA323230 90-L-100-KA-5-NN-80-R-4-C7-F-03-GBA-32-32-30 90L100KA5NN80R4C7F03GBA323230 90-L-100-KA-5-NN-80-R-4-F1-E-03-GBA-35-35-24 90L100KA5NN80R4F1E03GBA353524 90-L-100-KA-5-NN-80-R-4-F1-E-03-GBA-36-36-24 90L100KA5NN80R4F1E03GBA363624 90L100-KA-5-NN-80-R-4-F1-F-03-GBA-35-35-24 90L100KA5NN80R4F1F03GBA353524 90-L-100-KA-5-NN-80-R-4-F1-F-03-GBA-35-35-24 90L100KA5NN80R4F1F03GBA353524 90L100-KA-5-NN-80-R-4-T2-F-04-GBA-26-26-20 90L100KA5NN80R4T2F04GBA262620 90-L-100-KA-5-NN-80-R-4-T2-F-04-GBA-26-26-20 90L100KA5NN80R4T2F04GBA262620 90L100-KA-5-NN-80-S-3-C7-E-03-GBA-26-26-24 90L100KA5NN80S3C7E03GBA262624 90-L-100-KA-5-NN-80-S-3-C7-E-03-GBA-26-26-24 90L100KA5NN80S3C7E03GBA262624 90L100-KA-5-NN-80-S-3-C7-E-03-GBA-35-35-24 90L100KA5NN80S3C7E03GBA353524 90-L-100-KA-5-NN-80-S-3-C7-E-03-GBA-35-35-24 90L100KA5NN80S3C7E03GBA353524 90L100-KA-5-NN-80-S-3-C7-E-03-GBA-42-42-24 90L100KA5NN80S3C7E03GBA424224 90-L-100-KA-5-NN-80-S-3-C7-E-03-GBA-42-42-24 90L100KA5NN80S3C7E03GBA424224 90L100-KA-5-NN-80-S-3-C7-E-03-GBA-45-45-24 90L100KA5NN80S3C7E03GBA454524 90-L-100-KA-5-NN-80-S-3-C7-E-03-GBA-45-45-24 90L100KA5NN80S3C7E03GBA454524 90L100-KA-5-NN-80-S-3-C7-F-03-GBA-30-30-24 90L100KA5NN80S3C7F03GBA303024 90-L-100-KA-5-NN-80-S-3-C7-F-03-GBA-30-30-24 90L100KA5NN80S3C7F03GBA303024 90L100-KA-5-NN-80-S-3-C7-F-03-GBA-45-45-24 90L100KA5NN80S3C7F03GBA454524 90-L-100-KA-5-NN-80-S-3-C7-F-03-GBA-45-45-24 90L100KA5NN80S3C7F03GBA454524 90L100-KA-5-NN-80-S-3-F1-E-03-GBA-35-35-22 90L100KA5NN80S3F1E03GBA353522 90-L-100-KA-5-NN-80-S-3-F1-E-03-GBA-35-35-22 90L100KA5NN80S3F1E03GBA353522 90L100-KA-5-NN-80-S-3-S1-E-03-GBA-26-26-24 90L100KA5NN80S3S1E03GBA262624 90-L-100-KA-5-NN-80-S-3-S1-E-03-GBA-26-26-24 90L100KA5NN80S3S1E03GBA262624 90-L-100-KA-5-NN-80-S-3-S1-F-03-GBA-38-38-24 90L100KA5NN80S3S1F03GBA383824 90L100-KA-5-NN-80-S-3-S1-F-03-GBA-42-42-24 90L100KA5NN80S3S1F03GBA424224 90-L-100-KA-5-NN-80-S-3-S1-F-03-GBA-42-42-24 90L100KA5NN80S3S1F03GBA424224 90L100-KA-5-NN-80-S-4-C7-E-03-GBA-35-35-24 90L100KA5NN80S4C7E03GBA353524 90-L-100-KA-5-NN-80-S-4-C7-E-03-GBA-35-35-24 90L100KA5NN80S4C7E03GBA353524 90L100-KA-5-NN-80-S-4-C7-E-03-GBA-42-42-24 90L100KA5NN80S4C7E03GBA424224 90-L-100-KA-5-NN-80-S-4-C7-E-03-GBA-42-42-24 90L100KA5NN80S4C7E03GBA424224 90L100-KA-5-NN-80-S-4-C7-F-03-GBA-35-35-28-F023 90L100KA5NN80S4C7F03GBA353528F023 90-L-100-KA-5-NN-80-S-4-C7-F-03-GBA-35-35-28-F023 90L100KA5NN80S4C7F03GBA353528F023 90L100-KA-5-NN-80-S-4-T2-E-05-GBA-29-29-24 90L100KA5NN80S4T2E05GBA292924 90-L-100-KA-5-NN-80-S-4-T2-E-05-GBA-29-29-24 90L100KA5NN80S4T2E05GBA292924。
